Product ID:CPS 232507, VISTAC OIL 220X
MSDS Date:11/04/1985
FSC:9150
NIIN:00N030346
MSDS Number: BNNTT

CHEVRON

RICHMOND, CA 94804-0054
US

Emergency Phone: 800-457-2022

Info Phone: 801-524-7900

Cage: 0AHD1

CHEVRON ENVIRONMENTAL HEALTH CENTER INC

4054 RICHMOND, CA 94804 US

Telephone: 800-582-3835

Cage: 0AHD1

HIGHLY REFINED BASE OILS. MFR ALT CAS

Fraction By Weight: >95%

OSHA PEL 5 MG/M3;10 MG/M3STEL

ACGIH TLV: 5 MG/M3

INHIBITORS

Fraction By Weight: <5%

OILINESS & TACKINESS AGENTS

EXTREME PRESSURE AGENT CONTAINING INGREDIENT #5.

RTECS: 9999999ZZ

PHOSPHORODITHIOIC ACID, DIALKYL ESTER, ZINC SALT; (ZINC

CAS: 68649-42-3

RTECS: TD5550000

OSHA PEL 10 MG ZNO/M3

ACGIH TLV: 10 MG ZNO/M3

ALSO BEEN FOUND TO HAVE WEAK MUTAGENIC ACTIVITY

RTECS: 9999999ZZ

OCCURRED ONLY AT ZDDP CONCENTRATIONS WHICH WERE

RTECS: 9999999ZZ

OBTAINED, TAKE PERSON AND PRODUCT CONTAINER

RTECS: 9999999ZZ

FOLLOW PRESCRIBED PROCEDURES FOR REPORTING AND

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE:MINOR EYE IRRIT. SKIN: MINOR SKIN
IRRIT FOLLOWING PRLNGD/FREQUENTLY RPTD CONT. INHAL:NOT EXPECTED TO
BE ACUTELY TOX BY INHAL.BRTHG MINERAL OIL MIST AT CONC IN AIR THAT
EXCEED RECOM EXPOS STD CAN C AUSE RESP IRRIT/DISCOMFORT. INGEST:
NOTEXPECTED TO BE ACUTELY TOX BY INGEST. RABBITS DEVELOPED SEV SKIN
DMG,(SUPP DATA)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SIGNS AND SYMPTOMS OF RESPIRATORY TRACT
IRRITATION MAY INCLUDE, BUT MAY NOT BE LIMITED TO, ONE OR MORE OF
FOLLOWING, DEPENDING ON CONCENTRATION AND LENGTH OF EXPOSURE: NASAL
DISCHARGE, NOSEBLEED, SORE THROAT, COUGHING, BRONCHITIS, PULMONARY
EDEMA AND DIFFICULTY IN BREATHING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYES:FLUSH IMMED W/FRESH H2O FOR AT LEAST 15 MIN WHILE
HOLDING EYELIDS OPEN. IF IRRIT PERSISTS, SEE MD. SKIN: WASH SKIN
THORO W/SOAP & H2O. LAUNDER CONTAM CLTHG. INHAL: IF RESP
DISCOMFORT/ IRRIT OCCUR S, MOVE PERSON TO FRESH AIR. SEE MD IF
DISCOMFORT/IRRIT CONTINUES. INGEST: GIVE H2O/MILK TO DRINK &
TELEPHONE FOR MED ADVICE. CONSULT MED PERS BEFORE INDUCING VOMIT.
IF MED ADVICE CANNOT BE (ING 8)

Flash Point Method:COC
Flash Point:356F,180C
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.

Spill Release Procedures:STOP SOURCE OF LEAK/RELS. CLEAN UP RELS AS
SOON AS POSS.CONTAIN LIQ TO PVNT FURTHER CONTAM OF SOIL,SURF H2O/
GROUNDWATER. CLEAN UP SML SPILLS USING APPROP TECHNIQUES SUCH AS
SORBENT MATLS/PUMPING. WHE RE FEASIBLE & APPROP, REMOVE CONTAM
SOIL. (ING 9)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DO NOT WELD, HEAT OR DRILL CONTAINER.
RESIDUE MAY IGNITE WITH EXPLOSIVE VIOLENCE IF HEATED SUFFICIENTLY.
Other Precautions:CAUTION! DO NOT USE PRESSURE TO EMPTY DRUM OR
EXPLOSION MAY RESULT.

Respiratory Protection:NO SPECIAL RESPIRATORY PROTECTION IS NORMALLY
REQUIRED. HOWEVER, IF OPERATING CONDITIONS CREATE AIRBORNE
CONCENTRATIONS WHICH EXCEED RECOMMENDED EXPOSURE STANDARD, THE USE
OF A NIOSH/MSHA APPROVED RES PIRATOR IS RECOMMENDED.
Ventilation:USE ADEQUATE VENTILATION TO KEEP AIRBORNE CONCENTRATIONS OF
MATERIAL BELOW RECOMMENDED EXPOSURE STANDARD.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
HLTH HAZ: WEIGHT LOSS, & ADVERSE TESTICULAR EFTS. FOLLOW-UP STUDIES
INDICATED SIMILAR TESTICULAR EFTS CAN BE PRODUCED BY PLACING
RABBITS ON RESTRICTED DIET & CAUSING THEM TO LOSE WEIGHT/BY
TREATING RA BBITS W/SIMPLE CAUSTIC CHEM & CAUSING THEM TO DEVELOP
BOTH SEV SKIN IRRIT & WEIGHT LOSS. SEVERAL ZDDPS HAVE (ING 6)

HCC:V6
Spec Gravity:0.91 @ 15.6C
Solubility in Water:INSOLUBLE
Appearance and Odor:DARK AMBER LIQUID.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING MATERIAL.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NORMAL COMBUST FORMS CO2 & H2O VAP &
MAY PRODUCE SOX & PHOSPHOROUS; INCOMPLETE COMBUSTION CAN PRODUCE
CO.

Waste Disposal Methods:PLACE CONTAM MATLS IN DISPOSABLE CONTAINERS AND
DISPOSE OF IN MANNER CONSISTENT WITH APPLICABLE FEDERAL, STATE AND
LOCAL REGULATIONS. CONTACT LOCAL ENVIRONMENTAL OR HEALTH
AUTHORITIES FOR APPROVED DIS POSAL OF MATERIAL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.